How to oil fill gray transmission jack how to#

Repeat steps 1- 7 (alternating between D and R) five times. Home Vehicles How to Change Manual Transmission Oil on a Porsche Cayenne (2003-2010).

Drive backwards at part load approximately 10 meters (33 feet), then apply brake pedal to a stop and continue to apply brake pedal for approximately 10 seconds.

Drive forward at part load approximately 10 meters (33 feet), then apply brake pedal to a stop and continue to apply brake pedal for approximately 10 seconds.

With the ATF at a minimum 65Р В Р вЂ Р РЋРЎв„ўР вЂ™Р’В¬, carefully operate the vehicle in an open space (clear of traffic and obstacles).

6-7 quarts of Dexron VI transmission fluid, I used Valvoline synthetic. Funnel with attached tube, about 3/8' OD or equivalent for filling oil.

Confirm that the ATF is at a minimum 65Р В Р вЂ Р РЋРЎв„ўР вЂ™Р’В¬. Now on to the oil change: Youll need: 11mm socket+wrench for the drain and level plug removal and re-fitting.

With Gray employees serving on both the PASE and ALI boards, our team know the ins, outs and gravity of these lifting equipment industry standards. GrayР В Р вЂ Р В РІР‚С™Р Р†РІР‚С›РЎС›s WPLS are certified to all current Automotive Lift Institute standards. Now adapt the Transmission Control Module (TCM): Gray Manufacturing air jacks and floor jacks are created to meet or exceed ASME PASE-2014 standards.

Replace fill plug (new) and torque to spec.

If not add more fluid until it overflows and repeat the 3 previous steps until you have at temperature, and overflow. Once it gets to around 42oC (transmission) turn off.

You will need to ensure you have at VCDS to monitor the temps.

Apply brake and cycle through the gear selections slowly and methodically.

Rather than waste new engine oil, we filled it with some good used hydraulic oil and ran it long enough to steam clean it and move it into another bay (15-20 mins of basically idling). The tractor had been run long enough that the oil was a gray sludge.

Whilst up on the jack stands with all four wheels off the ground, start the car. After dropping the pan, we found that one of the sleeves was leaking.

Once it starts to run out again, replace the fill plug (old one) finger tight.

You'll need to stick the tube high up as possible into the fill hole.

Pump in fluid (OEM only) using a quart hand pump.

Pretty self explanatory, two hose couplings and some fasteners. If replacing the inline filter, do that now.

Replace with new drain plug and torque to correct settings.

Remove the drain plug (red) and drain all the fluid.

How to oil fill gray transmission jack crack#

Crack the fill plug first (yellow arrow) and make sure you can remove it.

Get it up level on four jack stands with enough space to get under the car safely.

Drive the car to operating temperature.

It now works like new and saved myself over Р В РІР‚в„ўР В РІвЂљВ¬100, fantastic Looking at new jacks they are quite expensive so I thought IР В Р вЂ Р В РІР‚С™Р Р†РІР‚С›РЎС›d service it replacing the oil and greasing the moving parts.

Jack works fine apart from it would slowly lower itself down under load. I have an old trolley jack that I inherited from my late father that is at least 25 years old. We carry specialty and general utility products, so you can do the job right.

How to oil fill gray transmission jack free#

Needed to service my log splitter and this was the best price. Get free next day delivery or same day pick up on the funnels you need to refill your vehicleР В Р вЂ Р В РІР‚С™Р Р†РІР‚С›РЎС›s fluids. Purged the air and my jack still works! It does seem to perform better so please about that with enough oil left for top up if ever it needs it. One definite recommendation: Remove the upper (fill) plug on the rear differential before removing the lower drain plug. Theres very informative threads in the DIY sub-forum here about changing gear oil. The oil came out (dirty) and the new oil went in. Consequently, if you decide to use the same gear oil in both the rear differential and the transmission, dont use Mobil 1.

How to oil fill gray transmission jack full#

The process of replenishing all the oil is quite straight forward and given the quantity in this bottle I thought it made sense to do a full change. Even worse most people only talk about the importance of flushing an automatic transmission. I bought this as it was on offer and wanted to ensure my jack was in good operational order before I used it as its about 20year old now. Manual Transmission Oil Change: Most people ignore transmission fluids. Bought a few weeks ago does what it says on bottle